A novel approach to create high-density magnetic data storage

The storage density of computer disks has been growing so rapidly that for new computer disk generations not only optimized materials are needed but also new concepts for data storage. Physicists from Dresden and Spain succeeded in generating minimized and ultra-flat structures. They recently published their novel approach in the journal "Small" .

In order to achieve higher storage densities on computer disks, the last decades were dominated by optimization of magnetic materials, i.e. the magnetic particles (grains) were gradually shrunk while, at the same time, the magnetic stability ( "magnetic anisotropy" ) was increased. Usually, about 100 to 600 grains form one bit, i.e. the nowadays smallest storage unit. Each grain is about 10 nanometers in size. These grains are arranged next to each other on glass substrates that are plated with cobalt, chrome, and platinum. Both the size and amount of the grains necessary for one bit could not be decreased further without decreasing the signal/noise ratio. Weaker signals could even be accompanied by loss of information. Therefore, new concepts of magnetic storage have to be found.

Pressemitteilung vom 12.01.2009: Neues Konzept zur Herstellung von magnetischen Datenspeichern aus Dresden

Physicists from the research centre Forschungszentrum Dresden-Rossendorf / FZD (Germany), the Universidad Autonoma de Barcelona (Spain) and further research institutions were able to generate magnetic areas which promise to overcome the obstacles of today’s data storage technology. Using a highly focused ion beam, i.e. fast charged atoms, they irradiated an iron-aluminum alloy in such a way that only the treated zones became ferromagnetic. As the ion beam is focused to a size of only a few nanometers and the ion dose is rather low, the created nanozones are extremely flat and significantly less than 100 nanometers in diameter.

The read/write heads of personal computer disks fly above the hard disks at a distance of 20 nanometers. Conventional technologies for structuring material surfaces on the nanoscale result in corrugated surfaces. These technologies are not suitable for hard disks because the generated bumpy nanostructures would interfere with the read/write heads and might finally destroy the disk.

The new superflat nanomagnets, however, fulfill all requirements concerning a new concept for magnetic data storage. In the future, each of these nanomagnets could serve as one bit, provided that they could be produced in parallel on large areas via lithographic techniques, and shrunk in size down to about 30 nanometers. “We are now working on the magnetic stability of our nanomagnets. Its increase would be a further step with respect to future industrial exploitation”, says Dr. Jürgen Fassbender, scientist at FZD.

Picture: An originally ordered binary alloy (white and red atoms) is disordered by means of focused ion irradiation (visualized as blue spheres in the 3D sketch). The disordered phase is magnetic and hence produces a magnetic field with north and south pole, similar to a bar magnet. The arrangement of north and south pole is used to store the information. Picture: Sander Münster, www.kunstkosmos.de(1)

Publication:

E. Menéndez*, M. O. Liedke*, J. Fassbender*, T. Gemming#, A. Weber~, L. J. Heyderman~, K. V. Rao+, S. C. Deevi$, S. Surinach§, M. D. Baro§, J. Sort§, J. Nogues§, "Direct Magnetic Patterning due to the Generation of Ferromagnetism by Selective Ion Irradiation of Paramagnetic FeAl Alloys", in: Small, 2009 (DOI: 10.1002/smll.200800783, publication in print). * Forschungszentrum Dresden-Rossendorf (FZD) / # Leibniz-Institut für Festkörper- und Werkstoffforschung (IFW) Dresden / ~ Paul-Scherrer-Institut (PSI), Schweiz / + Royal Institute of Technology Sweden / $ Research Center, Philip Morris USA / § Universitat Autònoma de Barcelona, Spain

Further information:
Dr. Jürgen Fassbender(2)
Institute of Ion-Beam Physics and Materials Research
Forschungszentrum Dresden-Rossendorf
Tel.: 0351 260 - 3096

Contact to the media:
Dr. Christine Bohnet(3)
Public Relations
Forschungszentrum Dresden-Rossendorf
Tel.: 0351 260 - 2450 / 0160 969 288 56
Fax: 0351 260 - 2700


URL of this article
https://www.hzdr.de/db/Cms?pOid=27942


Links of the content

(1) http://www.kunstkosmos.de
(2) mailto:j.fassbender@hzdr.de
(3) mailto:c.bohnet@hzdr.de